载马钱子碱纳米粒的微球系统的制备与初步评价

王建<sup>1; 2</sup>; 陈志鹏<sup>1; 2</sup>; 蔡宝昌<sup>1; 2; 3*</sup>

文章摘要

王建，陈志鹏，蔡宝昌.载马钱子碱纳米粒的微球系统的制备与初步评价[J].南京中医药大学学报(社会科学版),2013,29(1):56-59.

载马钱子碱纳米粒的微球系统的制备与初步评价

Preliminary Evaluation and Preparation of Brucine Nanoparticles-in-microsphere System

投稿时间：2012-09-28 修订日期：2012-10-30

DOI：

中文关键词: 马钱子碱纳米粒-微球系统喷雾干燥

英文关键词: brucine nanoparticles-in-microsphere system spray drying technique

基金项目:

作者	单位
王建^1，2，陈志鹏^1，2，蔡宝昌^1，2，3*	1.南京中医药大学药学院，江苏南京 210023；2.南京中医药大学国家教育部中药炮制规范化及标准化工程研究中心，江苏南京 210029；3.南京海昌中药集团，江苏南京 210061

摘要点击次数: 805

全文下载次数: 902

中文摘要:

目的制备包载马钱子碱纳米粒的壳聚糖微球系统（Brucine nanoparticles-in-microsphere system，Brucine-NiMS），以期获得一种降低突释作用用于关节腔注射的长效制剂。方法以牛血清白蛋白（BSA）为材料，采用去溶剂化法制备载马钱子碱的纳米粒（Brucine nanoparticles， Brucine-Nps）。再以壳聚糖(CS)为载体，利用喷雾干燥法将纳米粒包载于壳聚糖微球系统中。在电镜下观察Brucine-NiMS的外观，并测定其体外释放特性。结果 Brucine-NiMS的处方为：CS的型号为600 kDa，CS醋酸溶液的浓度为1%，BSA与CS的比例为1∶5。喷雾干燥的条件为：蠕动泵速度为20%，进口温度为120 ℃，Q-Flow为40 mL/h。在此条件下制备的Brucine-NiMS的包封率、载药量和粒径分别为97.35%、3.17%和1.48 μm。Brucine-NiMS外观圆整，性质稳定。结论 Brucine-NiMS制备方法稳定可控，为开发药物新剂型提供了新的思路。

英文摘要:

OBJECTIVE To find a long-acting preparation which can reduce the burst effect in intra-articular injection by preparing the brucine nanoparticles-in-microsphere system (Brucine-NiMS).METHODS Brucine nanoparticles (Brucine-Nps) were prepared by desolvation of BSA. Chitosan was used as an carrier and the nanoparticles were contained in the microsphere system by the spray drying method. The appearances of Brucine-NiMS were observed under the electron microscope and then the in vitro release characteristics were determined.RESULTS The formulation of Brucine-NiMS was as follows: BSA/CS (600KDA) 1∶5 (w/w) and the concentration of CS in the acetic acid was 1%. The spry drying conditions were as follows: The speed of the peristaltic pump was adjusted to 20%， the temperature of inlet was 120 ℃， and Q-Flow was 40 mL/h. The envelop rate， drug loading and particle sizes of Brucine-NiMS were 97.35%， 3.17% and 1.48 μm respectively. The appearance of Brucine-NiMS was rounding and the nature was stable.CONCLUSION The preparation method of Brucine-NiMS is stable and controllable， providing a new way to develop new dosage forms of drugs.

查看全文查看/发表评论下载PDF阅读器

关闭